 |
 |
 |
 |
 |
 |
||
 |
 |
 |
 |
 |
| 3 | 1/1 | 返回列表 |
| 查看: 616 | 回復: 2 | |||
| 本帖產生 1 個 翻譯EPI ，點擊這里進行查看 | |||
war3one金蟲 (著名寫手)
|
[求助]
求助一段翻譯,生物質預處理方向
|
||
|
相比于稀酸預處理,堿預處理可以更有效的提高酶解的效率,并且更低濃度的抑制物.但是限制其應用的原因一方面是其成本比稀酸高,另一方面是其處理液含有很高濃度的木質素,低濃度的單糖,難以像稀酸處理液一樣被利用.直接將堿處理液排放會嚴重的污染環境并且造成資源的浪費.如果利用硫酸將木質素回收,再次利用酸性的回收液處理生物質,不但可以利用副產物沖抵纖維素乙醇的成本,而且減少了處理廢水的成本,對堿預處理的發展有重大作用.預處理液糖的變化和抑制物的變化如表3和表4. 通過H2SO4可以回收2g的木質素,這些木質素被證明可以通過改性在工業領域有很廣泛的應用.通過高速離心以及活性炭脫毒后,處理液中的還原糖和抑制物都都顯著性的降低達到很低的水平,如果直接利用這個pH=8的回收液再次進行預處理,可能需要更高的預處理溫度,為了降低設備的要求,我們將硫酸的濃度補足到5%,在121度進行預處理10h,再次回收處理液后,還原糖的濃度達到了53g/L,其中木糖占有主要的地位,達到了73g/L.并且抑制物的濃度很低,低于堿處理液水平,但是出現了5-hydroxymethylfurfural.我們相信這么低的濃度對菌的生長影響是很小的.如果利用預處理液進行乙醇的生產是很不劃算的,因為其糖濃度過低,但是補加營養物質,比如酵母粉和蛋白胨,作為種子液增殖酵母是有利的.通過這種重復的預處理過程,回收了部分木質素和還原糖,不但達到了盡可能的充分利用生物質的目的,而且無廢液排放. |
回復此樓» 猜你喜歡
材料學碩333求調劑
已經有5人回復
-
321求調劑
已經有6人回復
-
一志愿鄭州大學，080500學碩，總分317分求調劑
已經有4人回復
-
求調劑
已經有6人回復
-
327求調劑
已經有7人回復
-
349求調劑
已經有3人回復
-
325求調劑
已經有3人回復
-
0856材料專碩353求調劑
已經有7人回復
-
調劑求收留
已經有3人回復
-
調劑
已經有4人回復
andrewzhang
鐵桿木蟲 (著名寫手)
超級無敵加菲
- 翻譯EPI: 119
- 應助: 225 (大學生)
- 金幣: 6404.9
- 散金: 410
- 紅花: 45
- 帖子: 1428
- 在線: 485小時
- 蟲號: 923911
- 注冊: 2009-12-09
- 性別: GG
- 專業: 玻璃材料
【答案】應助回帖
★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ★ ...
war3one: 金幣+180, 翻譯EPI+1, ★★★★★最佳答案, 謝謝了 2013-08-01 16:48:15
war3one: 金幣+180, 翻譯EPI+1, ★★★★★最佳答案, 謝謝了 2013-08-01 16:48:15
| When comparing to the pre-treatment by attenuated acid, the pre-treatment by basic solution was more powerful for raising the efficiency of enzymatic hydrolysis, and could work under less inihibitant. Yet its utilization was also limited, in respect that on one hand, the costs are higher than attenuated acid, on the other hand, the treated solution could not be discharged as easy as that of attenuated acid pre-treatment, because of the existence of high concentration of lignin and low concentration of monosaccharide. The direct discharge of basic treated solution would cause serious pollution and also a waste of source. But if the solution was treated by sulfuric acid to recover the lignin, the solution can be recovered and reused to treat raw materials, it is a very interesting research for the basic pre-treatment, it would not only reduce the cost by using the by-product in the place of cellulose alcohol, but also reduce the founds that spent on treatment of waste solution. The concentration changes of saccharides and inihibitants were showed in figure 3 and figure 4, respectively. |
2樓2013-07-26 17:17:35
andrewzhang
鐵桿木蟲 (著名寫手)
超級無敵加菲
- 翻譯EPI: 119
- 應助: 225 (大學生)
- 金幣: 6404.9
- 散金: 410
- 紅花: 45
- 帖子: 1428
- 在線: 485小時
- 蟲號: 923911
- 注冊: 2009-12-09
- 性別: GG
- 專業: 玻璃材料
【答案】應助回帖
| 2 g of lignin could be recovered by H2SO4, and these lignins were proven to can be used in various industrial domains after modification. The waste solution of pre-treatment, after been treated by centrifugation and acticarbon, showed a obvious decrease in the level of both saccharides and inihibitants. To use these recovered solutions, the concentration of pre-treatment solution must be raised, to reduce the requirement for equipment. The concentration of H2SO4 was replenished to 5%, pre-treatment lasted for 10h at 121 degree. The solution after the 2nd pre-treatment was analysed, and concentration of sacchariedes reached to 53g/L, among which the xylose was the principal material, with concentration of 73g/L. What's more, the concentration of inihibitant was very low, even lower than that of solution before pre-treatment, but 5-hydroxymethylfurfural was found (we believe such a small concentration could not great effect to the growth of bacteria). It is not so ideal to use this solution to product the C2H6O, because its sacchariede concentration was too low; but the solution was favorable as proliferation of yeast for seeding emulsion, after addition of nitration like yeast powder or peptone. By repeating this pretreatment process, the lignin and sacchariede could be recovered, purpose of full utilization of raw materials was achieved, in addition, no waste emission was issued. |
3樓2013-07-26 17:53:49
相關版塊跳轉
我要訂閱樓主 war3one 的主題更新
| 3 | 1/1 | 返回列表 |
| 最具人氣熱帖推薦 [查看全部] | 作者 | 回/看 | 最后發表 | |
|---|---|---|---|---|
|
[考研] 329求調劑 +11 | 想上學吖吖 2026-03-19 | 11/550 |
|
|---|---|---|---|---|
|
|
[考研] 0703化學求調劑 +3 | 丹青奶蓋 2026-03-26 | 5/250 |
|
|
[考研] 0703化學338求調劑！ +4 | Zuhui0306 2026-03-26 | 4/200 |
|
|
|
[考研] 打過很多競賽，085406控制工程300分，求調劑 +3 | askeladz 2026-03-26 | 3/150 |
|
|
|
[考研] 調劑310 +3 | 溫柔的晚安 2026-03-25 | 4/200 |
|
|
|
[考研] 07化學303求調劑 +5 | 睿08 2026-03-25 | 5/250 |
|
|
|
[考研] 08工學調劑 +13 | 用戶573181 2026-03-20 | 18/900 |
|
|
|
[考研] 一志愿中南大學化學學碩0703總分337求調劑 +7 | niko- 2026-03-22 | 7/350 |
|
|
|
[考研] 生物技術與工程 +3 | 1294608413 2026-03-25 | 4/200 |
|
|
|
[考研] 302求調劑 +4 | 錦衣衛藤椒 2026-03-25 | 4/200 |
|
|
|
[考研] 0854電子信息求調劑 +7 | α____ 2026-03-22 | 9/450 |
|
|
|
[考研] 0854人工智能方向招收調劑 +4 | 章小魚567 2026-03-24 | 4/200 |
|
|
|
[考研] 282求調劑 +3 | wcq131415 2026-03-24 | 3/150 |
|
|
|
[考研] 一志愿武理085500機械專業總分300求調劑 +3 | an10101 2026-03-24 | 7/350 |
|
|
|
[考研] 070300，一志愿北航320求調劑 +3 | Jerry0216 2026-03-22 | 5/250 |
|
|
|
[考研] 材料與化工085600，總分304，本科有兩篇sci參與，求調劑 +4 | 幸運的醬醬 2026-03-22 | 5/250 |
|
|
|
[考研] 生物學調劑 +5 | Surekei 2026-03-21 | 5/250 |
|
|
|
[考研] 材料與化工（0856）304求B區調劑 +3 | 邱gl 2026-03-20 | 7/350 |
|
|
|
[考研] 一志愿 南京航空航天大學大學 ，080500材料科學與工程學碩 +5 | @taotao 2026-03-20 | 5/250 |
|
|
|
[考研] 261求B區調劑，科研經歷豐富 +3 | 牛奶很忙 2026-03-20 | 4/200 |
|